IKT

IKT – Institute for Underground Infrastructure

Project F198:
Optimising sewer cleaning, exploiting operational synergies

Posted 01. August 2012
0 Comments

Cleaning is an important factor in maintaining the correct functioning of sewer system, and absorbs a significant portion of municipal budgets in North Rhine-Westphalia. It is, however, often the case that system operators’ resources are not used efficiently, or that, due to inadequate knowledge of the condition of sewer systems, lengths of sewer are cleaned without this being really necessary. The introduction of optimising sewer cleaning strategy is frequently cited…


Project W036:
Adhesion properties of short-liners

Posted 01. September 2011
0 Comments

Short lengths of selected repair systems were tested under external water pressure to examine their potential for sealing pipes against groundwater pressure. Comparative tensile-adhesion tests were undertaken using four short-liner systems on eleven different surfaces in order to determine the factors influencing performance and any need for surface preparation when refurbishing using short-liners. The systems predominantly exhibited good performance, and confirmed that repairs aimed at sealing against external water pressure…


IKT Comparative Test “Odour filters”

Posted 28. May 2010
0 Comments

In the summer months, in particular, odour emissions from sewers cause odour nuisances and thus higher levels of complaints from residents. Sewer-system operators are in general obliged to find a remedy for such problems. Odour filters installed in waste-water manholes are coming into increasing use. In addition, further products which release special active ingredients in the waste-water manhole shaft are also used. The aim of this Comparative Test was that…


IKT Comparative Test “Sewer lateral liners 2010”

Posted 15. May 2010
0 Comments

IKT has investigated the material quality and practical usability of CIPP liner products for sewer laterals in the context of an extensive programme of tests. Practically orientated tests performed in the test pipes at the IKT’s large-scale test facility were the focus of this programme. The IKT Comparative Test “Sewer lateral liners” provides drain/sewer operators with reliable and impartial information on the product properties of commercially available refurbishing procedures.


IKT Comparative Test
“Repair methods for main sewers”

Posted 23. August 2009
0 Comments

Many waste-water system operators are unsure of what can be achieved by main sewer repair methods and what quality is attainable. Twelve different techniques from the three groups of methods: “Injection/grouting + injection methods”, “Short-liners” and “Internal sleeves” have been comparatively tested under defined and replicable conditions using the IKT Comparative Test “Repair methods for main sewers”. The principal focus was the testing of the techniques in IKT test rigs…


IKT Comparative Test
“Sewer lateral liners 2005”

Posted 22. November 2005
0 Comments

This IKT Comparative Test assesses the suitability and the practical usability of CIPP liners available on the market for sewer laterals. The central focus is on highly practically orientated comparison of the products, in order to be able to provide waste-water system operators with impartial and technically substantiated information on the strengths, weaknesses and potentials/limitations for use of the products tested. The test programme itself has been developed jointly with…